Preview

Material Safety Data Sheet

Satisfactory Essays
Open Document
Open Document
769 Words
Grammar
Grammar
Plagiarism
Plagiarism
Writing
Writing
Score
Score
Material Safety Data Sheet
MATERIAL SAFETY DATA SHEET PRODUCT NAME: EPO-TEK 353ND, Part A

EPOXY TECHNOLOGY 14 FORTUNE DRIVE BILLERICA, MA 01821 EMERGENCY PHONE: US/CANANDA : 800-255-3924 INT’L COLLECT: + 813-248-0585 DATE REVISED: 4/30/2009 REV: D

*HMIS: HEALTH-2 FIRE-1 REACTIVITY- 0

Carcinogen: NTP (No) IARC (No) OSHA (No)

* HMIS CODE ratings are estimated by Epoxy Technology. ____________________________________________________________

________________________________ I. IDENTIFICATION & PHYSICAL DATA PERCENT VOLATILE: NA VAPOR PRESSURE: NA BOILING POINT: NA SOLUBILITY IN WATER: Low VAPOR DENSITY: >Air EVAPORATION RATE: NA APPEARANCE: Clear liquid SPECIFIC GRAVITY: 1.2 ODOR: Mild ____________________________________________________________

________________________________ II. HAZARDOUS INGREDIENTS CAS # WT % Epoxy Phenol Novolac 28064-14-4 75-100%

TOXICITY DATA Acute Oral Effects (LD50): Rat > 10,000 mg/kg Acute Dermal Toxicity (LD50): Rabbit 3,000 mg Inhalation Toxicity (LD50): LCLO = 1.7 mg ____________________________________________________________

________________________________ III. FIRE & EXPLOSION DATA FLASH POINT: >200F EXTINGUISHING MEDIA: Dry chemical, foam, carbon dioxide. UNUSUAL FIRE & EXPLOSION HAZARDS: Avoid fumes liberated by heat. SPECIAL FIRE FIGHTING PROCEDURES: Wear self contained breathing apparatus and complete personal protective equipment. Remove all ignition sources. Use a water spray to cool fire exposed containers. ____________________________________________________________

________________________________ IV. REACTIVITY DATA STABILITY: Do not exceed 25 grams during mixing and curing. HAZARDOUS POLYMERIZATION: Will not occur if mix< 25 grams. CONDITIONS TO AVOID: Excessive heat MATERIALS TO AVOID: Strong oxidizing and reducing agents. HAZARDOUS DECOMPOSITION PRODUCTS: Fumes produced when heated to decomposition may include carbon monoxide, and carbon dioxide. ____________________________________________________________
Continue Reading
View Writing Issues

You May Also Find These Documents Helpful

  • Powerful Essays

    Nt1310 Unit 3 Assignment 3
    • 4996 Words
    • 20 Pages

    Nt1310 Unit 3 Assignment 3

    This document is copyrighted by the National Fire Protection Association (NFPA), 1 Batterymarch Park, Quincy, MA 02269-9101 USA.…

    • 4996 Words
    • 20 Pages
    Powerful Essays
    Read More
  • Good Essays

    Cdl Review
    • 630 Words
    • 3 Pages

    Cdl Review

    A guidebook for firefighters, police, and industry workers on how to protect themselves and the public from hazardous materials.…

    • 630 Words
    • 3 Pages
    Good Essays
    Read More
  • Satisfactory Essays

    Case Study: Type of Industry
    • 457 Words
    • 2 Pages

    Case Study: Type of Industry

    The customers gave ManuFactu-R-US an average of 2.4 for ManuFactu-R-US’ on-site safety levels. There was a significant amount of standard deviation, with many customers giving safety level ratings between 1 and 4. The maximum safety level rating recorded was 10 and the minimum rating was 1.…

    • 457 Words
    • 2 Pages
    Satisfactory Essays
    Read More
  • Better Essays

    CIS 502 BUSINESS CONTINUITY AND DISASTER RECOVERY PLANNING
    • 1114 Words
    • 10 Pages

    CIS 502 BUSINESS CONTINUITY AND DISASTER RECOVERY PLANNING

    From U.S. national Institute for Standards and Technology. business community program.  From U.S. National Fire protection association.…

    • 1114 Words
    • 10 Pages
    Better Essays
    Read More
  • Better Essays

    How to Read Material Safety Data Sheets
    • 1201 Words
    • 5 Pages

    How to Read Material Safety Data Sheets

    EXAMPLE Blue = Health hazard Red = Fire hazard Yellow = Reactivity hazard White = Special hazard…

    • 1201 Words
    • 5 Pages
    Better Essays
    Read More
  • Better Essays

    Qcf 643
    • 1083 Words
    • 5 Pages

    Qcf 643

    | Describe how and when the different types of fire extinguishers, relevant to the given occupation, are used in accordance with legislation and official guidance.…

    • 1083 Words
    • 5 Pages
    Better Essays
    Read More
  • Powerful Essays

    Report Ld 50 of Cockroaches
    • 1605 Words
    • 7 Pages

    Report Ld 50 of Cockroaches

    The LD50 for one species is very different from another. In each LD50 test there is considerations that need to be understood such as age, weight, sex, health and diet (David Rall, Ph.D., former Director, National Toxicology Program “Inadequacy of the LD50 test” Found at http://www.pcrm.org/resch/anexp/LD50.htm). Each individual factor cannot be accurately monitored for each individual animal if randomly acquired. This is only one of the reasons why the LD50 test is not quite useful as it does not maintain a biological constant and that value therefore has little significance in testing toxicity.…

    • 1605 Words
    • 7 Pages
    Powerful Essays
    Read More
  • Satisfactory Essays

    Distillation and Concentrated Sulfuric Acid
    • 331 Words
    • 2 Pages

    Distillation and Concentrated Sulfuric Acid

    The purpose of this lab was for students to familiarize and perfect the simple distillation method to produce 4-Methylcyclohexene and to gain experience using an IR spectroscopy to characterize the product of the reaction in favor of equilibrium.…

    • 331 Words
    • 2 Pages
    Satisfactory Essays
    Read More
  • Powerful Essays

    BUS 311 Final Paper
    • 1826 Words
    • 5 Pages

    BUS 311 Final Paper

    References: Consumer Products Safety Commission (2001) Fireworks Business Guidance Retrieved on August 24, 2014 from https://www.cpsc.gov/en/Business--Manufacturing/Business-Education/Business-Guidance/Fireworks/…

    • 1826 Words
    • 5 Pages
    Powerful Essays
    Read More
  • Good Essays

    Security Objective Component
    • 669 Words
    • 3 Pages

    Security Objective Component

    References: Arrigoni, Barbara. (March, 2009). Homeland1. Calif. County almost ready to trigger arson, bomb task force. Retrieved: November 2, 2010. From: http://www.homeland1.com/homeland-security-products/decontamination-decon-equipment/articles/457847-calif-county-almost-ready-to-trigger-arson-bomb-task-force/…

    • 669 Words
    • 3 Pages
    Good Essays
    Read More
  • Satisfactory Essays

    Unit 5 OSHA Paper
    • 429 Words
    • 2 Pages

    Unit 5 OSHA Paper

    OSHA stands for the Occupational Safety and Heath Administration, which is a US agency for the Department of Labor. OSHA’s priority is the safety of workers and health protection. OSHA was created and passed by Congress in 1970. Until 1970, there were no US laws protecting employee’s safety and health in the work force and this is why OSHA came to be. There are workers who do not qualify for protection by OSHA; public employees, mine workers, truck and transportation workers, atomic energy employees, immediate members of farming families who do not employ outside employees, and the self employed. Some employees are covered by other plans and federal agencies. OSHA’s mission is to provide job training programs that increase employees knowledge about safety and health in the work place, developing job safety and health standards by enforcing them through inspections and maintaining records system of keeping track of accidents and illnesses on the job. About 5500 people die each year from work related injuries. Over 4 million non-fatal injuries and illnesses are reported each year.…

    • 429 Words
    • 2 Pages
    Satisfactory Essays
    Read More
  • Good Essays

    Health and Safety Mu.2.4
    • 674 Words
    • 3 Pages

    Health and Safety Mu.2.4

    * Know where extinguishers are kept and how to use them, know where all fire exits are…

    • 674 Words
    • 3 Pages
    Good Essays
    Read More
  • Powerful Essays

    cu2963
    • 874 Words
    • 4 Pages

    cu2963

    ensure we can reduce fire risk from dangerous substances and where possible eliminate this risk…

    • 874 Words
    • 4 Pages
    Powerful Essays
    Read More
  • Good Essays

    Classifying chemical reaction
    • 2467 Words
    • 10 Pages

    Classifying chemical reaction

    1. Which reactants used in this experiment are flammable? Discuss the safety precautions that are necessary when working with flammable materials in the lab?…

    • 2467 Words
    • 10 Pages
    Good Essays
    Read More
  • Better Essays

    Cause And Effect Of Fire Essay
    • 1233 Words
    • 5 Pages

    Cause And Effect Of Fire Essay

    Class D fires, which are also known as combustible metals, can burn with intense heat. Fire fighters need to do their best to avoid having water coming in contact with these kinds of products, such as magnesium and gasoline. According to Robert Vettori, “Magnesium has a strong affinity for oxygen that it attracts the oxygen from oxygen containing compounds” (5). With this said, it shows that the two products burning are both magnesium and an adequate supply of oxygen. The National Fire Protection Association Fire Protection Handbook expresses that water may used to extinguish magnesium fires if it can be applied very quickly as well as in large enough quantities in order to have some type of cooling effect. Class B fires, which are also…

    • 1233 Words
    • 5 Pages
    Better Essays
    Read More

Related Topics